Char-Broil RED 466250511 Guide de l'utilisateur

IMPORTANT: Refer t o the instructions inside when converting this grill to Natural Gas.Assembly instructions © 2010PRODUCT GUIDEMODEL 466250511© 2

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LIST 11NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However,

PARTS DIAGRAM12ABCDEGHIJKWWLMNOPQQRRSTUVWXYZAABBBBCCDDEEFFGGHHIIJJKKLLMMNNOOPPQQRRSSTTUUVVWWF

13ASSEMBLY21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws per panel. IMPORTANT: Panel with large hole mustbe on l

1434This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom

1565On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel in lower holes using one 1/4-20x

167Attach right side fascia to right side shelf using four #10-24x3/8” screws, 5mm lock washers and 5mmflat washers, shown A.DE#10-24x3/8” Screw5mm Lo

817left side shelfAttach left side fascia to left side shelf using four #10-24x3/8” screws, 5mm lock washers and 5mmflat washers, shown A.Insert flang

918Position sideburner valve bracket beneath sideburner shelf fascia so that valve stem comes through larger center hole in fascia. Align the holes on

1019Insert sideburner into left shelf. The stud on bottom of the burner fits into the rear small hole in sideburner drip pan, shown A.Under sideburner

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

11 2012Inside of cart, insert rear tabs(w/o holes) of tank heat shield into slots on the bottom of upper back panel.Attach front tabs(w/holes) of tank

1321Insert the pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door, and release hi

15 22Place cooking grates onto the firebox as shown.Place the Warming Rack onto the the firebox. Make sure insert the Warming Rack ends into the hole

23 1Main Burner ConversionYour grill may differ from illustration shown. This portion of the manual covers a variety of grill styles. Use pictures

24 4BezelsValveStemScrewsMain Burner Control KnobsNatural Gas Bezel80007893Pull the Burner Control Knobs off of Valve Stems.Remove Screws and Washe

25 6 7Open Sideburner lid and remove the Sideburner Grate.Beneath Sideburner shelf, remove Wingnut.Remove Sideburner from shelf.WingnutSideburner Gra

26 89Pull the Sideburner Control Knob off of Valve Stem. Remove the existing Bezel by removing the two Screws and Washers securing Bezel to shelf f

27 11 Using the provided Orifice Removal Tool, unscrew the Orifice from the end of the Sideburner Valve. Save removed Orifice and Orifice Removal To

1213Pull the Sideburner Control Knob off of Valve Stem. Remove the existing Bezel by removing the two Screws and Washers securingBezel to shelf fascia

14Natural Gas Hose Conversion Using a wrench, not provided, remove LP Regulator Hose Assembly from Manifold Connection. Save removed LP Manifold Conn

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

Connecting Your Grill to the Natural Gas Source. 1. A professionally-installed shut-off valve between the supply piping and the socket is recommended,

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

NOTES34

35 Warranty Registration DepartmentP.O. Box 1240Columbus, GA 31902-1240

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

WARNINGFor Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from

Ignitor Check•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time betwe

9 CAUTION•Clean cooking grates.•Store in dry location.•When LP cylinder is connected to grill, store outdoors in a well-ventilated space and out of r